Natural Weathering of Mineral Stabilized Asphalt Coatings on Organic FeltU.S. National Bureau of Standards, 1969 - 15 pages Sixteen years of outdoor weathering of laboratory-prepared smooth-surface and mineral-surfaced, felt-base roofing specimens has provided information on the effects of mineral additives on the durability of coating-grade roofing asphalts. Six finely divided mineral additives (blue black slate, clay, dolomite, fly ash, mica, and silica) were evaluated at concentrations up to 60 percent in California, Mid Continent and Venezuela asphalts. The mineral-surfaced specimens are all performing satisfactorily, and show only minor degrees of degradation. Of the smooth-surfaced specimens, the Mid-Continent asphalt performed the best and the California asphalt the poorest. The mica and blue black slate increased the durabilities of all three asphalts at all concentrations and two coating thicknesses. Fly ash, clay, dolomite, and silica were beneficial in some combinations, but had little effect in others. In general, these early results from outdoor exposure tend to corroborate the results obtained on these coatings exposed in weatherometers. (Author). |
From inside the book
Results 1-4 of 4
Page 1
... observe it over the years . For materials or systems of low life expectancy , this procedure has been proven extremely satisfactory . For building materials , where the life expectancy is of the order of decades , the observed ...
... observe it over the years . For materials or systems of low life expectancy , this procedure has been proven extremely satisfactory . For building materials , where the life expectancy is of the order of decades , the observed ...
Page 7
... observed early in the exposure period consisted of small losses of granules in most of the specimens and heavier losses of granules in the few specimens in which poor granule adhesion was measured prior to exposure . After about 12 ...
... observed early in the exposure period consisted of small losses of granules in most of the specimens and heavier losses of granules in the few specimens in which poor granule adhesion was measured prior to exposure . After about 12 ...
Page 10
... observed . Fifty percent clay in- creased the durability of the California asphalt in both thicknesses by 60 percent . Fifty percent dolo- mite improved the thin films of both Mid - Continent and Venezuela asphalt by 30 percent ...
... observed . Fifty percent clay in- creased the durability of the California asphalt in both thicknesses by 60 percent . Fifty percent dolo- mite improved the thin films of both Mid - Continent and Venezuela asphalt by 30 percent ...
Page 14
... observed . ( 5 ) Based on the smooth - surface specimens , the results in the weatherometer tests in most instances predicted the relative durabilities of the coating . Where the weatherometers were different , the difference was in the ...
... observed . ( 5 ) Based on the smooth - surface specimens , the results in the weatherometer tests in most instances predicted the relative durabilities of the coating . Where the weatherometers were different , the difference was in the ...
Common terms and phrases
60 percent aluminum aluminum-base specimens appearance Applied areas asphalt coatings ASTM base Black Slate 25 blistering Blue Black Slate Building Building Science Series Bureau of Standards California asphalt Cement Center cents Characteristics Clay Column COMMERCE concentrations consists containing corresponding cracking criteria deterioration differences direction divisions doctor bar Dolomite durability early effects exposed exposure failed failure felt-base specimens FIGURE Fly Ash Government granule-surfaced specimens granules grid half heated industry Institute Kraft paper listed longer Loss on ignition losses machine materials measurement method Mica Mid-Continent asphalt mils mineral additives Months Ratio Months National Bureau observed Office Organic panel passed performances period physical prepared procedure produced Properties provides Ratio Months Ratio reference reported Research rolls roofing saturated felt sheets shingle Silica smooth smooth-surface smooth-surface specimens spalling surface TABLE technical Technology temperature tests three asphalts Venezuela asphalt Washington weather weatherometer tests